Another Rookie Question on Smoked Sausage
-
Yes, it is cooked before eating.
Simmered in kraut w/ potatoes, or with pierogies.
Or grilled. -
MT Elk Hunter - I’m using natural hog casings.
-
mikesr how many hours does it take to reach your desired internal temp? Are you running of water and experiencing a stall?
-
mikesr how many hours does it take to reach your desired internal temp? Are you running of water and experiencing a stall?
-
unclelar1 - Thanks. Are you able to freeze/thaw/cook and get the same results? Do you use cure? Natural casings?
mikesr Yes , I vacuum seal and feeze.
It always taste better fresh but you dont lose much in the freezer, especially with the vac seal.I use all natural hog casing. and I use the proper ratio of pink cure on all my smoked sausage and jerky
my kielbasa is the only smoked sausage I smoke at a lower temp.
my sticks and salami etc. I always smoke til proper internal of finish in my slow cook oven till proper temp. -
mikesr Yes , I vacuum seal and feeze.
It always taste better fresh but you dont lose much in the freezer, especially with the vac seal.I use all natural hog casing. and I use the proper ratio of pink cure on all my smoked sausage and jerky
my kielbasa is the only smoked sausage I smoke at a lower temp.
my sticks and salami etc. I always smoke til proper internal of finish in my slow cook oven till proper temp. -
mikesr I never smoke my sausage that hot.
Because I always cook it some way before I eat it.
I make allot of kielbasa, and I hang overnight in cooler. Then smoke for 10 hrs and never let smoker get over 125* I start slow and it usually takes about 2 hrs to get to my maintain temp.
Rarely is casings tougher than a light snap.
Once in a while I get tough casing but attribute it to bad casingsunclelar1 That is how I do a smoked sausage when I do large barbecues. I fully cook it prior to serving. Always a very light snap at best. Very tender.
-
unclelar1 That is how I do a smoked sausage when I do large barbecues. I fully cook it prior to serving. Always a very light snap at best. Very tender.
-
I posted a while back about tough natural skins on smoked sausage. Thank you for your much needed advice that I have put into practice. I purchased an Auber temperature controller (a great product) to more precisely control temperature and employed Jonathan’s smoke schedule:
125 - 1 hour
140 - 1hour
155 - 1 hour
175 to 160 degrees internal
The sausage has a fantastic flavor, but skins are still leathery to the point of being unchewable. I pretty much follow the procedures shown in the Meatgistics recipes and videos. I rinse and soak the fresh casings overnight before stuffing. I humidify the smoker cabinet with a water pan. This last batch, I soaked them in an ice bath after they reached the proper internal temperature. That helped a little, but not nearly enough. The skins are still inedible. FYI, we do enjoy a snap, but these don’t snap, they tear. Any suggestions would be much appreciated. Thanks. -
mikesr Try holding your sausage overnight in a tub of Tupperware with a lid in a room that is slightly chilled. The condensation from the residual heat off the sausage will soften the skins.
-
Post smoking
-
MT Elk Hunter So I agree but I have documentation from Devro that says otherwise, which is a great example of how anyone can make any study say anything they want! Im guessing humidity is your major issue, usually, when I have a tougher casing something went wrong with humidity in the smoker. If you haven’t already check out this post https://meatgistics.waltonsinc.com/topic/1099/cured-sausage-205-advanced-thermal-processing
Recently I have found that using a shammy type material works even better, it takes up a little more space but it was able to completely empty an oversized water bowl in the PK in just a few hours.
-
MT Elk Hunter So I agree but I have documentation from Devro that says otherwise, which is a great example of how anyone can make any study say anything they want! Im guessing humidity is your major issue, usually, when I have a tougher casing something went wrong with humidity in the smoker. If you haven’t already check out this post https://meatgistics.waltonsinc.com/topic/1099/cured-sausage-205-advanced-thermal-processing
Recently I have found that using a shammy type material works even better, it takes up a little more space but it was able to completely empty an oversized water bowl in the PK in just a few hours.
-
I never thermal process sticks while smoking them. I smoke below 150F until they have the color I like-nice deep cherry color using the smoked collagen 19mm casings.
Then into water bath to cook to 155F then shower with cold water. I don’t get dry sticks, I don’t get dry chewy skins. Been doing it tho way for decades.
Hello! It looks like you're interested in this conversation, but you don't have an account yet.
Getting fed up of having to scroll through the same posts each visit? When you register for an account, you'll always come back to exactly where you were before, and choose to be notified of new replies (either via email, or push notification). You'll also be able to save bookmarks and upvote posts to show your appreciation to other community members.
With your input, this post could be even better 💗
Register LoginSponsored By:
