Bacon Salty
-
processhead - Just used waltons dry rub bacon mix. 8 oz, for 10 pounds if I remember correctly. Was barley enough to cover all sides.
lkrfletcher said in Bacon Salty:
processhead - Just used waltons dry rub bacon mix. 8 oz, for 10 pounds if I remember correctly. Was barley enough to cover all sides.
Its too bad that the salt amount is not listed in the ingredients.
I saw where Jonathon said once that Excalibur doesn’t even tell Walton’s what the salt amount is in their dry rub bacon cure.Just for comparison, I looked up how much dry rub I use for a 10 lb belly using the diggin dog farms EQ calculator.
The total weight of cure which is just salt, sugar, and cure #1 is just under 5 ounces for a 10 lb pork belly. That is based on 2% salt, 1% sugar and .02% cure #1 by weight of the uncured pork belly.
It also assumes using EQ curing methods, and just a quick fresh water rinse before smoking. No extended soaking.The Excalibur dry cure at 8 ounces for a 10 lb belly is significantly more curing product. What is not known is if they use additional ingredients besides sugar, salt and nitrite or if they use more of the dry cure to be on the safe side?
My guess, and it is nothing more than that, is that the Excalibur dry rub cure has significantly more salt and they are counting on removing a portion of that with one or more fresh water soaks after curing.
The problem may be with variations in how much excess salt is being removed with the fresh water soak step and subsequent differences in the salt left behind in the finished belly prior to smoking.
-
johnsbrewhouse I have used ziplock bags and vac bags and the results have been the same, do what you like on the bag and smoking, but the rest needs to remain the same to produce a quality consistent product.
mrobisr I have quite a few two gallon ziploc bags and the bellies fit much better in the ziplocs. The chamber bags are much better quality and don’t tend to leak, but I put them in a container either way. When I use the chamber bags I just seal them, never pull a vacuum.
-
gus4416 - Thanks, I cant eat any kind of sugar or carbs.
-
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
lkrfletcher before chucking it, see if your friends enjoy it. I find that lots of friends enjoy my mistakes if I don’t. When you feed them something even better you are a total genius in their eyes.
-
I made some Canadian bacon a few months ago, it’s a little salty, but when you add a couple of fried eggs to it, the saltiness balances out.
-
My first batch of bacon was too salty, I just rinsed and smoked, on my latest batch I soaked for a while AND before smoking I fried up a bit to see taste…Sample before smoking is my new rule of thumb.
-
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
lkrfletcher said in Bacon Salty:
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
Well that sucks. I followed the same procedure. That first five pounds I did I just guessed at how much rub to use. The second one, which I actually just did, I measured out 4oz. This was according to the conversion chart. Thought this looked like way to much. Will see what happens in a few days.
That first one I pulled after six days. Thought it was a to salty for my taste. After a few days in the freezer it seemed better…Weird. This one I just did I’m going to pull after five days and give it a couple extra rinses. I didn’t vacuum seal the first one and not going to on this one either.
Don’t give up. Keep an eye out for a sale on bellies. Sounds like you paid a lot for that one. $2.04lb at the store the other day. Kicking myself for not getting a couple more. After giving out samples to the family they seem to think their bacon buying days are over. LOL
-
mrobisr I have quite a few two gallon ziploc bags and the bellies fit much better in the ziplocs. The chamber bags are much better quality and don’t tend to leak, but I put them in a container either way. When I use the chamber bags I just seal them, never pull a vacuum.
johnsbrewhouse i I could not get the bellies into the large ziplocks, would’nt fit.
Life is a Garden - Dig it.
-
lkrfletcher said in Bacon Salty:
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
Well that sucks. I followed the same procedure. That first five pounds I did I just guessed at how much rub to use. The second one, which I actually just did, I measured out 4oz. This was according to the conversion chart. Thought this looked like way to much. Will see what happens in a few days.
That first one I pulled after six days. Thought it was a to salty for my taste. After a few days in the freezer it seemed better…Weird. This one I just did I’m going to pull after five days and give it a couple extra rinses. I didn’t vacuum seal the first one and not going to on this one either.
Don’t give up. Keep an eye out for a sale on bellies. Sounds like you paid a lot for that one. $2.04lb at the store the other day. Kicking myself for not getting a couple more. After giving out samples to the family they seem to think their bacon buying days are over. LOL
PapaSop - That is strange, mine was actually pretty good on the test batch, a little salty. After the freeze, they are way too salty now.
-
johnsbrewhouse i I could not get the bellies into the large ziplocks, would’nt fit.
lkrfletcher said in Bacon Salty:
johnsbrewhouse i I could not get the bellies into the large ziplocks, would’nt fit.
The one I just started. Just over 5lbs. 2gal ziplock.
-
johnsbrewhouse i I could not get the bellies into the large ziplocks, would’nt fit.
lkrfletcher You have to find the two gallon size, they won’t fit in one gallon bags. I use the two gallons for almost everything I brine, hams, corned beef, chickens, they are a perfect size for 5-6 lbs. of bacon slab plus have space to spare.
-
A question for the group. The Bacon I made is very salty - Wondering what I could have done different?
Here is what I did:- Dry rubbed for 7 days under vacuum
- Removed from vac bags and washed thoroughly for 20 minutes
- Soaked in cold fresh water 30 minutes
- Repeated the above steps 2 more times.
- Soaked 3 hours in water
- Dried with paper towels and added pepper and jalepeno flakes - Refrigerated overnight
- Ran the Smoke schedule
- Refrigerated overnight
- Sliced and stored
Maybe not a full 7 days? - I had very little liquid in the Vac bags after the 7 days.
I was sure I rinsed it enough, but it is too salty - Too expensive to keep making it this way if it is going to be this salty.lkrfletcher I did not vacuum pack mine, just sealed it in a meat lug. I also smoked it after 6 days. The thickness of the belly has a lot to do with the cure time. Wish I could help more, but I am new to this also. Sorry it did not turn out for you.
-
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
lkrfletcher after curing and soaking you can slice of a piece and fry it up to test for saltiness. If too salty change water and soak it more.
I think you used the pre-made rub. Try playing with the eq method and just plug weight into the calculator and it gives you your ingredient weight. You can adjust the salt percent and sugar percent to your liking. Most people I have seen seem to prefer 1.8% to 2.0% for salt. There is no need to rinse after the eq method.
DO NOT GIVE UP!!! You can do this! -
johnsbrewhouse i I could not get the bellies into the large ziplocks, would’nt fit.
lkrfletcher I cut mine in half or thirds. I seal mine in my chamber vac and the largest bag I can use is 10x13. Also that way I can experiment with different ratios and flavors all from one belly. Just weigh each piece and then measure rub for each piece individually or rub the whole belly with measured cure and then cut to size.
-
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
lkrfletcher It is still usable and salvageable. Baked beans for sure, chowders, etc… But you can still get the salt out by soaking and rinsing. It is a PIA, but you have a product you just need to do some corrections to bring it to where you want it.
-
lkrfletcher said in Bacon Salty:
This is a tough one - At $50 or so for the belly and the rub, this is a costly mistake. There is clearly more to this than the video or instructions let on. Some can get it, some can not it appears. PapaSop got his first try, I was hoping for the same. Into the trash it goes - Wife calls it inedible. Darn. I will watch posts more carefully and try and learn more before I make this mistake again.
Well that sucks. I followed the same procedure. That first five pounds I did I just guessed at how much rub to use. The second one, which I actually just did, I measured out 4oz. This was according to the conversion chart. Thought this looked like way to much. Will see what happens in a few days.
That first one I pulled after six days. Thought it was a to salty for my taste. After a few days in the freezer it seemed better…Weird. This one I just did I’m going to pull after five days and give it a couple extra rinses. I didn’t vacuum seal the first one and not going to on this one either.
Don’t give up. Keep an eye out for a sale on bellies. Sounds like you paid a lot for that one. $2.04lb at the store the other day. Kicking myself for not getting a couple more. After giving out samples to the family they seem to think their bacon buying days are over. LOL
PapaSop $ 2.04/lb ??? Holy cow. The cheapest I have seen is $3.99 /lb at Costco. That’s pretty much the o ly.place I can find it around me and that is over 1 hour away. There is one butcher shop I had found it in but I am thinking he wanted somewhere around $6.00 /lb. That’s part of the problem I guess where I am. I have lots of butcher places but everyone sells bacon so I am sure they would rather make bacon to sell themselves than sell the belly and possibly loose some profit?
-
Dice it up and fry it with potatoes. Potatoes absorb salt and will help balance it out. Add eggs and it’s breakfast! I have thrown a raw potato into a pot of chili that was inadvertently over salted. The potato pulled enough salt from the pot that the meal was saved. I agree with others that mention not vacuum sealing. I made bacon commercially for awhile. We wet brined and vacuum tumbled them in order to smoke them that same day. If you do vacuum, dramatically reduce the time you are brining. Don’t give up! The homemade stuff will be so worth it.
-
Don’t throw it out! The very first bacon I made a few years ago, I had no idea what I was doing. I covered the entire pork belly with tender quick for a week. Needless to say, it was so salty it was inedible. I soaked it in a tub of cold water in the fridge changing out the water every 8 hours. Every day after work I would cut a small piece off and test fry it. It took 4 days before it was edible and 5 days it was good to eat. Try that before throwing it out.
-
Dice it up and fry it with potatoes. Potatoes absorb salt and will help balance it out. Add eggs and it’s breakfast! I have thrown a raw potato into a pot of chili that was inadvertently over salted. The potato pulled enough salt from the pot that the meal was saved. I agree with others that mention not vacuum sealing. I made bacon commercially for awhile. We wet brined and vacuum tumbled them in order to smoke them that same day. If you do vacuum, dramatically reduce the time you are brining. Don’t give up! The homemade stuff will be so worth it.
Deepwoodsbutcher - Thanks. BTW - I can’t eat potato
-
Dice it up and fry it with potatoes. Potatoes absorb salt and will help balance it out. Add eggs and it’s breakfast! I have thrown a raw potato into a pot of chili that was inadvertently over salted. The potato pulled enough salt from the pot that the meal was saved. I agree with others that mention not vacuum sealing. I made bacon commercially for awhile. We wet brined and vacuum tumbled them in order to smoke them that same day. If you do vacuum, dramatically reduce the time you are brining. Don’t give up! The homemade stuff will be so worth it.
Deepwoodsbutcher I would think since lkrfletcher dont eat taters, he could just throw the tater away after it draws some of the salt out. Taters are alot cheaper then pork bellies
Hello! It looks like you're interested in this conversation, but you don't have an account yet.
Getting fed up of having to scroll through the same posts each visit? When you register for an account, you'll always come back to exactly where you were before, and choose to be notified of new replies (either via email, or push notification). You'll also be able to save bookmarks and upvote posts to show your appreciation to other community members.
With your input, this post could be even better 💗
Register LoginSponsored By:
