What is Weisswurst?

Weisswurst is a Bavarian sausage usually partially made from some veal and pork bacon. Seasonings can vary, but lemon, onion, and parsley are traditional. Must be cooked in water to avoid a Maillard reaction or charring. We chose to sous vide our sausage. This also helps with keeping the conventional white color. This sausage is full of flavor but does offer an excellent base if wanting to experiment with other flavors. Of course, serving with mustard is a MUST!

Meat Block

30% lb of Pork Shoulder
70% lb of Rose Veal
Weisswurst Seasoning
12 oz Ice Water
2 oz of Cold Phosphate per 25 lb of meat

Equipment

Walton’s #22 Meat Grinder
Walton’s One Shot Grinder Head
Walton’s 30 lb Electric Sausage Stuffer

Prep & Grind

Cut your meat up into small enough to fit down the throat of your grinder. We used the Walton’s #22 and we used the Walton’s One-Shot Grinder Head attachment. This replaces the entire head assembly of your grinder and can take you from whole muscle to second grind 1/8" plate meat that would be ready for snack sticks, summer sausage, or any cured sausage. Even though this is a fresh sausage we still want to run it through a 1/8" plate at least. Weisswurst is supposed to have a hotdog-like texture, so it needs to be broken down thoroughly. If you have access to one bowl or buffalo chopper or mincer can be used to achieve the desired level of emulsification. If you do use a chopper or mincer, you need to add ice water to keep the meat cold.

Additives & Meat Mixing

This is a special fresh sausage, so we want to be careful with the additives we are using. Weisswurst is supposed to be a white-colored sausage even after it has been cooked so we do not want to add anything that could change that color. We added 2 oz of Cold Phosphate directly to our water and stirred it until it was totally dissolved. The phosphate is going to increase the pH of the meat which increases the water-holding capacity of the meat. We then will add the seasoning and the water to the meat and mix it until we are just shy of full protein extraction. Remember, we want a smoother texture than a normal fresh sausage here.

Sausage Stuffing

We are using 30mm Fresh Collagen for this, which I would highly recommend. The reason for this is that we are going to cook these in hot water and then peel the casing off the sausage before serving, and the collagen will naturally want to peel off sausage when it is cooked in water. We used our new 30 lb Electric Sausage Stuffer for these, and even with the reduced water content, the stuffer worked wonderfully.

Appearance

Weisswurst is supposed to be a white sausage after it is cooked, so we have a limited number of ways we can prepare it. We cannot grill or overheat it as we will create a Maillard reaction, we can’t smoke it as we might have too much smoke adhesion. So, the best way we know how to do this is with a Sous Vide cooker.

Cook In Water

Set a sous vide cooker, or stabilize a pot of water at 180° and cook until the internal temp is 160°. A good rule of thumb is 1 minute of cook time for every millimeter of diameter. Now, there are two schools of thought on an ice bath here. Some say bring it to the table in the hot water and some want the ice bath. We did not use an ice bath and the casing peels much easier when the sausage was still hot, but do with that information what you will, there is no wrong answer here.

Serving

Bring to the table and serve hot with some Tangy Mustard, a Bavarian pretzel goes VERY well with them. Remember this is supposed to be eaten before the noon bell, so eat up!

Watch Walton’s: Specialty Sausage: 202 Weisswurst

Shop waltonsinc.com for Fresh Collagen Casings

Shop waltonsinc.com for Weisswurst Seasoning

Shop waltonsinc.com for Sausage Stuffers